Sufentanil Labatec

Sufentanil Labatec is indicated for the management of acute moderate to severe post-operative pain in adult patients.

Sufentanil Labatec is to be administered in a hospital setting only. Sufentanil Labatec should only be prescribed by physicians who are experienced in the management of opioid therapy, particularly opioid adverse reactions such as respiratory depression.

Posology

Sufentanil Labatec sublingual tablets are to be self-administered by the patient in response to pain using the Sufentanil Labatec administration device. The Sufentanil Labatec administration device is designed to deliver a single sufentanil 15 micrograms sublingual tablet, on a patient-controlled as needed basis, with a minimum of 20 minutes (lockout interval) between doses, over a period of up to 72 hours, which is the maximum recommended treatment duration. See section “Method of administration”.

Elderly

No special population studies were performed using sufentanil sublingual tablets in elderly patients. In clinical trials approximately 30 % of enrolled patients were 65 to 75 years of age. The safety and efficacy in elderly patients was similar to that observed in younger adults.

Hepatic or renal impairment

No special population studies were performed using sufentanil sublingual tablets in hepatic and renal impaired patients. Only limited data are available for the use of sufentanil in such patients. Sufentanil Labatec should be administered with caution to patients with moderate to severe hepatic or severe renal impairment.

Paediatric population

The safety and efficacy of Sufentanil Labatec in children aged below 18 years have not been established. No data are available.

Method of administration

For sublingual use only.

The Sufentanil Labatec sublingual tablets are to be self-administered using the Sufentanil Labatec administration device which should only be actuated by the patient in response to pain.

The dispensed sublingual tablet should dissolve under the tongue and should not be crushed, chewed, or swallowed.

-

- Significant respiratory depression.

Respiratory depression

Sufentanil may cause respiratory depression, for which the degree/severity is dose related. The respiratory effects of sufentanil should be assessed by clinical monitoring, e. g. respiratory rate, sedation level and oxygen saturation. Patients at higher risk are those with respiratory impairment or reduced respiratory reserve. Respiratory depression caused by sufentanil can be reversed by opioid antagonists. Repeat antagonist administration may be required as the duration of respiratory depression may last longer than the duration of the effect of the antagonist.

Intracranial pressure

Sufentanil should be used with caution in patients who may be particularly susceptible to the cerebral effects of CO₂ retention, such as those with evidence of increased intracranial pressure or impaired consciousness. Sufentanil may obscure the clinical course of patients with head injury. Sufentanil should be used with caution in patients with brain tumours.

Cardiovascular effects

Sufentanil may produce bradycardia. Therefore, it should be used with caution in patients with previous or pre-existing bradyarrhythmias.

Sufentanil may cause hypotension, especially in hypovolemic patients. Appropriate measures should be taken to maintain stable arterial pressure.

Impaired hepatic or renal function

Sufentanil is primarily metabolised in the liver and excreted in the urine and faeces. The duration of activity may be prolonged in patients with severe hepatic and renal impairment. Only limited data are available for the use of Sufentanil Labatec in such patients. Patients with moderate to severe hepatic or severe renal impairment should be monitored carefully for symptoms of sufentanil overdose.

Abuse potential and tolerance

Sufentanil has potential for abuse. This should be considered when prescribing or administering sufentanil where there is concern about an increased risk of misuse, abuse or diversion.

Patients on chronic opioid therapy or opioid addicts may require higher analgesic doses than the Sufentanil Labatec administration device can deliver.

Gastrointestinal effects

Sufentanil as a µ-opioid receptor agonist may slow the gastrointestinal motility. Therefore, Sufentanil Labatec should be used with caution in patients at risk of ileus.

Sufentanil as a µ-opioid receptor agonist may cause spasm of the sphincter of Oddi. Therefore, Sufentanil Labatec should be used with caution in patients with biliary tract disease, including acute pancreatitis.

Other

Before use, the health-care professional should ensure that the patients have been appropriately instructed on how to operate the Sufentanil Labatec administration device to self-administer tablets as needed to manage their pain post-operatively. Only patients who are able to understand and follow the instructions to operate the administration device should use Sufentanil Labatec. The health-care professional should take into consideration the ability (e. g. visual or cognitive) of the patient to use the device appropriately.

Excipients

Sufentanil Labatec sublingual tablets contain the azo colouring agent sunset yellow FCF Aluminium Lake (E110), which may cause allergic reactions.

Sufentanil has major influence on the ability to drive and use machines. Patients should be advised not to drive or operate machinery if they experience somnolence, dizziness, or visual disturbance while taking or after the treatment with Sufentanil Labatec. Patients should only drive and use machines if sufficient time has elapsed after the last administration of Sufentanil Labatec.

Summary of the safety profile

The most serious adverse reaction of sufentanil is respiratory depression, potentially leading to apnoea and respiratory arrest.

Based on the combined safety data from these clinical studies, nausea and vomiting were the most frequently reported adverse reactions (>1/10 frequency).

Tabulated list of adverse reactions

Adverse reactions identified either from clinical studies or from post-marketing experience with other medicinal products containing sufentanil are summarised in the table below. The frequencies are defined as:

* see “Description of selected adverse reactions”

Description of selected adverse reactions

After prolonged use of other substances with µ-opioid receptor activity, symptoms of withdrawal were observed after abrupt interruption of the treatment.

Some adverse reactions were not observed in the clinical trials with Sufentanil Labatec. Their frequencies were established based on data from intravenous administration of sufentanil: common - muscle twitching; uncommon - hypersensitivity, apathy, nervousness, ataxia, dystonia, hyperreflexia, heart rate decreased and dry skin.

Reporting of suspected adverse reactions

Reporting suspected adverse reactions after authorisation of the medicinal product is important. It allows continued monitoring of the benefit/risk balance of the medicinal product. Healthcare professionals are asked to report any suspected adverse reactions via:

United Kingdom

Yellow Card Scheme

Website: www.mhra.gov.uk/yellowcard

Ireland

HPRA Pharmacovigilance

Earlsfort Terrace

IRL - Dublin 2

Tel: +353 1 6764971

Fax: +353 1 6762517

Website: www.hpra.ie

e-mail: [email protected]

Signs and symptoms

Sufentanil overdose is manifested by an exaggeration of its pharmacological effects. Depending on individual sensitivity, the clinical picture is determined by the degree of respiratory depression. This may range from hypoventilation to respiratory arrest. Other symptoms that may occur are loss of consciousness, coma, cardiovascular shock and muscle rigidity.

Management

Management of overdose should be focused on treating symptoms of µ-opioid receptor agonism including administration of oxygen. Primary attention should be given to obstruction of airways and the necessity of assisted or controlled ventilation.

An opiate antagonist (e.g. naloxone) should be administered in the event of respiratory depression. This does not rule out more direct countermeasures. The shorter duration of activity of the opiate antagonist compared to sufentanil should be taken into account. In that case, the opioid antagonist can be administered repeatedly or by infusion.

Pharmacotherapeutic group: Analgesics, opioids, ATC Code: N01AH03

Mechanism of action

Sufentanil is a synthetic, potent opioid with highly selective binding to µ-opioid receptors. Sufentanil acts as a full agonist in µ-opioid receptors.

Sufentanil does not induce histamine release. All effects of sufentanil can immediately and completely be blocked by administration of a specific antagonist such as naloxone.

Primary pharmacodynamics effects

Analgesia

Analgesia induced by sufentanil is thought to be mediated via activation of µ-opioid receptors primarily within the CNS to alter processes affecting both the perception of and the response to pain. In humans the potency is 7 to 10-fold higher than fentanyl and 500 to 1,000-fold higher than morphine (per oral). The high lipophilicity of sufentanil allows it to be administered sublingually and achieve a rapid onset of analgesic effect.

Secondary pharmacodynamics effects

Respiratory depression

Sufentanil may cause respiratory depression and also suppresses the cough reflex.

Other CNS effects

High doses of intravenously administered sufentanil are known to cause muscle rigidity, probably as a result of an effect on the substantia nigra and the striate nucleus. Hypnotic activity can be demonstrated by EEG alterations.

Gastrointestinal effects

Analgesic plasma concentrations of sufentanil may provoke nausea and vomiting by irritation of the chemoreceptor trigger zone.

Gastrointestinal effects of sufentanil comprise decreased propulsive motility, reduced secretion and increased muscle tone (up to spasms) of the sphincters of the gastrointestinal tract.

Cardiovascular effects

Low doses of intravenous sufentanil associated with likely vagal (cholinergic) activity cause mild bradycardia and mildly reduced systemic vascular resistance without significantly lowering blood pressure.

Cardiovascular stability is also the result of minimal effects on cardiac preload, cardiac flow rate and myocardial oxygen consumption. Direct effects of sufentanil on myocardial function were not observed.

Clinical efficacy and safety

Analgesia

Efficacy of Sufentanil Labatec for patient-controlled analgesia was demonstrated in 3 Phase III clinical trials in acute post-surgical nociceptive and visceral pain (post-surgical pain following major abdominal or orthopaedic surgery): 2 trials were double-blind placebo-controlled (Sufentanil Labatec N = 430 patients; placebo N = 161 patients) and 1 was an open-label active-controlled (Sufentanil Labatec N = 177 patients; morphine N = 180 patients) trial.

Patients were treated using the Sufentanil Labatec dosing regimen of 15 micrograms sufentanil sublingually as needed with a minimum 20 minute lock-out interval over a period of 72 hours.

Superiority over placebo was demonstrated in the Phase III placebo-controlled trials for the primary endpoint time-weighted sum of pain intensity difference from baseline over 48 hours (SPID48; P ≤0.001), and the secondary endpoints, time-weighted SPID (P ≤0.004), total pain relief (TOTPAR; P ≤0.004), and patients global assessment (P ≤0.007) over 24, 48 and 72 hours. After 48 hours more than half of the subjects in the Sufentanil Labatec group had a relevant pain reduction (30 % responder rate) in these trials (visceral pain 60 %, nociceptive pain 54.9 %).

A significantly higher proportion of patients (78.5 %) rated the method of pain control as “good” or “excellent” with Sufentanil Labatec than with intravenous morphine patient-controlled analgesia method (65.5 %) (primary endpoint at 48 hours; P = 0.007). Patients reported in all the 3 Phase III trials a clinically meaningful pain relief within the first hour of treatment with Sufentanil Labatec (pain intensity difference to baseline and total pain response >1 NRS). Sufentanil Labatec was also considered to be easier to use by health-care professionals (P = 0.017).

As demonstrated in the active-controlled trial, the average time between Sufentanil Labatec doses was approximately double as long as compared to intravenous morphine patient-controlled analgesia (approximately 80 minutes compared to approximately 45 minutes) over the first 48 hours.

Patients who were treated with Sufentanil Labatec between 48 and 72 hours in the three controlled trials used a wide range of the available 216 doses, with a mean of 49 doses/patient (range of 8-153 doses) with the majority of patients (69.7 %) using between 24 to 72 doses.

Respiratory depression

Analgesic doses of Sufentanil Labatec resulted in respiratory depressive effects in some patients in the clinical trials. In the Phase III active-controlled trial, the magnitude of decrease in oxygen saturation was comparable between Sufentanil Labatec and i.v. patient-controlled morphine groups. However, there was a statistically significant lower percentage of patients who experienced oxygen desaturation episodes following the administration of Sufentanil Labatec sublingual tablets (19.8 %) with the administration device than in the IV PCA morphine group (30.0 %). Clinical trials have shown that sufentanil administered intravenously causes less respiratory depression when compared with equianalgesic doses of fentanyl.

Absorption

The pharmacokinetics of sufentanil after sublingual administration can be described as a three-compartment model with first-order absorption. This route of administration results in higher absolute bioavailability by avoiding intestinal and first-pass liver 3A4 enzyme metabolism.

Mean absolute bioavailability after a single sublingual administration of Sufentanil Labatec relative to a one-minute intravenous sufentanil infusion of 15 micrograms was 59 %. This compares to a substantially lower bioavailability of 9 % after oral intake (swallowed). In clinical trials during repeated administrations the bioavailability decreased to 37.6 %.

Buccal administration study showed an increased bioavailability of 78 % when the tablets were placed in front of the front lower teeth.

Maximum concentrations of sufentanil are achieved approximately 50 minutes after a single dose; this is shortened to approximately 20 minutes following repeat dosing. When Sufentanil Labatec was administered every 20 minutes, steady state plasma concentrations were achieved after 13 doses.

Distribution

The central volume of distribution after intravenous application of sufentanil is approximately 14 litres and the volume of distribution at steady state is approximately 350 litres.

Biotransformation

Biotransformation takes place primarily in the liver and the small intestine. Sufentanil is mainly metabolised in humans by the cytochrome P450-3A4 enzyme system. Sufentanil is rapidly metabolised to a number of inactive metabolites, with oxidative N- and O-dealkylation being the major routes of elimination.

Elimination

The total plasma clearance after single intravenous administration is about 917 l/min.

Approximately 80 % of the intravenously administered dose of sufentanil is excreted within 24 hours. Only 2 % of the dose is excreted in unchanged form. Clearance is not affected by race, sex, renal parameters, hepatic parameters, or concomitant CYP3A4 substrates.

Clinically relevant plasma levels are largely determined by the time for the sufentanil plasma concentration to drop from C_max to 50 % of C_max after discontinuation of dosing (context sensitive half-time or CST½) rather than by the terminal half-life. After a single dose, the median CST½ was 2.2 hours, increasing to a median value of 2.5 h after multiple dosing: the sublingual delivery route thus substantially extends the duration of action associated with intravenous sufentanil administration (CST½ of 0.14 hours). Similar CST½ values were observed following both single and repeated administration demonstrating that there is a predictable and consistent duration of action after multiple dosing of the sublingual tablet.

After single administration of a 15 micrograms sufentanil sublingual tablet, mean terminal phase half-lives in the range of 6 to 10 hours have been observed. After multiple administrations, a longer mean terminal half-life of up to 18 hours was determined, owing to the higher plasma concentrations of sufentanil achieved after repeated dosing and due to the possibility to quantify these concentrations over a longer time period.

Special populations

Renal impairment

A population pharmacokinetic analysis of plasma sufentanil concentrations following usage of Sufentanil Labatec in patients and healthy volunteers (N = 700), which included 75 patients with moderate and 7 patients with severe renal impairment, did not identify renal function as a significant covariate for clearance. However, due to the limited number of patients with severe renal impairment studied, Sufentanil Labatec should be used with caution in such patients.

Hepatic impairment

Based on the population pharmacokinetic analysis for Sufentanil Labatec in patients and healthy volunteers (N = 700), which included 13 patients with moderate and 6 patients with severe hepatic impairment, hepatic function was not identified as a significant covariate for clearance. Due to the limited number of patients with moderate to severe hepatic impairment, a potential effect of hepatic dysfunction as covariate on clearance may not have been detected. Therefore, Sufentanil Labatec should be used with caution in such patients.

Paediatric population

No pharmacokinetic data exist for the Sufentanil Labatec in paediatric patients.

There is limited pharmacokinetic data available in children after intravenous sufentanil administration.

Elderly

No special population studies were performed using Sufentanil Labatec in the elderly. Pharmacokinetic data from intravenous sufentanil administration did not reveal age related differences. In the placebo-controlled Phase 3 trials, approximately 20 % of enrolled patients were elderly (> 75 years of age) and approximately 30 % of enrolled patients were 65 to 75 years of age. The population pharmacokinetic analysis showed an effect of age with a 27 % decrease in clearance in the elderly people (above 65 years of age). Since this decrease related to age is smaller than the observed inter-subject variability of 30-40 % in exposure parameters for sufentanil, this effect is not considered to be of clinical relevance, particularly given that Sufentanil Labatec is only used on an 'as-needed' basis.

Population pharmacokinetics

When patients titrated themselves to analgesic effect with Sufentanil Labatec, plasma sufentanil concentrations averaged 60-100 pg/ml over two days of use, with no effect based on age or body mass index (BMI), or mild to moderate renal or liver impairment.

Patients with BMI > 30 kg/m²

Population pharmacokinetic analysis with a BMI as covariate showed that patients with a BMI > 30 kg/m² dosed more frequently.

Repeat-dose toxicity

Sufentanil has been shown to induce opioid-like effects in a variety of laboratory animals (dogs, rats, guinea pigs, hamsters) at doses above those inducing analgesia and in two repeat-dose studies with sufentanil sublingual tablets administered buccally in Golden Syrian hamster.

Reproductive toxicity

Sufentanil was not teratogenic in rats and rabbits. Sufentanil caused embryolethality in rats and rabbits who were treated for 10-30 days during pregnancy with 2.5 times the maximum human dose by intravenous administration. The embryolethal effect was considered secondary to the toxicity for the mother animal.

No negative effects were observed in another study in rats that were treated with 20times the maximum human dose in the period of organogenesis. The preclinical effects were only observed following administrations of levels significantly above the maximum human dose, which are therefore of little relevance for clinical use.

Mutagenicity

The Ames test revealed no mutagenic activity of sufentanil. In the micronucleus test in female rats, single intravenous doses of sufentanil as high as 80 µg/kg (approximately 2.5 times the upper human intravenous dose) produced no structural chromosome mutations.

Carcinogenicity

Carcinogenicity studies have not been conducted on sufentanil.

Local tolerance

Two local tolerance studies were conducted in the hamster cheek pouch with the sufentanil sublingual tablets. It was concluded from these studies that Sufentanil Labatec sublingual tablets have no or minimal potential for local irritation.

Not applicable.

The cartridge should be used only with the Sufentanil Labatec administration device, consisting of a controller and a dispenser to ensure the proper use of this system.

After removing from the sachet, the cartridge should be placed into the Sufentanil Labatec administration device immediately.

The device should be used as recommended in the information provided by the device manufacturer.

The instructions for setting up the Sufentanil Labatec administration device by a healthcare professional must be followed carefully.

The Sufentanil Labatec administration device should not be used if any component is visibly damaged.

The fully charged Sufentanil Labatec administration device will operate without recharging for up to 72 hours.

After treatment discontinuation the health-care professional has to remove the cartridge from the device and any unused and/or not completely empty cartridges have to be disposed by the health-care professional in accordance with local laws and requirements for controlled substances. Any other waste material must be discarded in accordance to the institutional policies and local requirements.